||Applies to all Wynn's products with the following prefix:
|Wynn's Professional Products
Oil System Cleaner & Conditioner
||61603, 61607,61610, 61614
|COMMON NAME||CHEMICAL NAME||CAS NO.||OSHA PEL||ACGIH TLV-TWA|
Contains no other ingredients now known to be hazardous as defined by OSHA 29CFR 1910.1000(z) and 29CFR 1910.1200.
These data are approximate or typical values and should not be used as precise specifications. Unless otherwise noted values are at 20°C(68°F) and 760 mmHg (1 atm)
|Specific Gravity (H20=1) @ 15.625C
||Vapor Pressure (mm Hg)
|Vapor Density (Air =1)
||Heavier Than Air
||Solubility in Water (%)
|% Volatiles by Volume
||Evaporation Rate (Butyl Acetate = 1)
|pH (as is)
||pH (dilute) @ %
||Clear Brown Thin Liquid
N/D - Not Determined
< = Less Than
N/A - Not Applicable
> = Greater Than
FIRE AND EXPLOSION HAZARD DATA
Flash Point: 47525°F(24625°C) Method Cleveland Open Cup ASTM D-92
Flammable or Explosive Limits (Approximate percent by volume in air)
Lower (LEL) N/D Upper (UEL) N/D
Hazard Class Identification
0 - Least (insignificant)
1 - Slight
2 - Moderate
3 - High
4 - Extreme
Dry chemicals, carbon dioxide, water spray, foam.
Special Fire Fighting Procedures
Use water only to cool fire exposed containers. Fire fighters wear a self contained breathing apparatus.
Unusual Fire and Explosion Hazards
The material is combustible and may be ignited by heat or flame.
Conditions to Avoid
Heat, open flame.
Materials to Avoid
Strong oxidizing agents.
Hazardous Decomposition or Combustion Products
Thermal decomposition may produce oxides of carbon, nitrogen, phosphorus, and zinc.
Hazardous Polymerization Will not occur.
HEALTH HAZARDS/ROUTES OF ENTRY
Signs, Symptoms and Effects of Overexposure
Ingestion (swallowing)May be harmful or fatal if swallowed. Due to its low viscosity, it may enter lungs during swallowing or vomiting. Once in lungs serious damage may occur.
Skin Contact Can be absorbed through skin on prolonged contact. Single contact, no effect likely. Prolonged and repeated contact can result in defatting and drying of the skin. Can cause redness and itching.
Eye Contact May cause irritation, burning, blurred vision and redness.
Inhalation (breathing) Inhalation can cause irritation to nose and throat and upper respiratory tract. Concentrated vapor respiration can cause dizziness, nausea and central nervous system damage.
Other Effects of Prolonged/Repeated Overexposure
This material has not been identified as a carcinogen by NTP, IARC or OSHA. Kidney damage may occur if large quantities are swallowed.
EMERGENCY AND FIRST AID PROCEDURES
Ingestion (swallowing) DO NOT induce vomiting. Call for medical help.
Skin Contact Wash affected area with soap and water. Remove contaminated clothing.
Eye Contact Flush with water for 15 minutes. If irritation persists call for medical help.
Inhalation (breathing) Remove person to fresh air to avoid further inhalation.
Comments NOTE TO PHYSICIANS: Treatment should be based on symptoms and clinical condition.
SPILL OR RELEASE CONTROL PROCEDURES
Steps to be taken in case material is released or spilled
Ventilate area. Avoid breathing of vapors. Remove with inert absorbent.
Waste Disposal Method
Dispose of in accordance with Federal, State and Local regulations.
ENVIRONMENTAL HAZARD (EPA-CWA, SECTION 311)
Spills of this material leading to surface waters where it will cause a sheen must be reported to the National Response Center (800) 424-8802.
EPA Reportable Quantity (RQ), 40CFR302 (CERCLA104)
EPA Toxic Chemical Release Reporting, 40CFR372(SARA313)
|Chemical ||CAS NO. ||% in Product|
|Zinc Compound ||-||1.75|
HANDLING AND STORAGE
Handling and Storage Precautions
WARNING: Contains petroleum distillates. Avoid skin and eye contact. Avoid breathing of vapors. Combustible. Keep away from heat and sparks. Use entire contents. DO NOT store opened containers.
KEEP AWAY FROM CHILDREN.
PERSONAL PROTECTION - EXPOSURE CONTROL
Provide adequate general or local ventilation to maintain concentrations below TLV/PEL limits.
None normally required. If vapors exceed TLV/PEL values, use a NIOSH approved respirator
Safety glasses with side-shields.
Other Protective Clothing or Equipment
Eye wash station is recommended.
Personal cleanliness is always appropriate. Frequent washing minimizes chances of inadvertent exposure.
Department of Transportation (DOT) Classification
||Non Flammable Gas|
||Non Hazardous by DOT|
DOT Proper Shipping Name
DOT ID Number
Product Code No.: 61603, 61607, 61610, 61614
Previous Code No.: 61603, 61607, 61609, 61610, 61611, 61614, 61616, 61629, 61630
Issue Date: 08-30-05
Prior Date: 06-18-04
This information is, to the best of our knowledge and belief, accurate and reliable as of the date compiled. However, no representation, warranty or guarantee is made as to its accuracy, reliability or completeness. It is the user's responsibility to satisfy himself as to the suitability and completeness of such information for his own particular use.