|PRODUCT NAME||EFFECTIVE DATE||PRODUCT CODE|
|Wynn's Diesel Charge Diesel Fuel Treatment||01-31-06 ||18001 |
|CHEMICAL NAME||CAS NUMBER|
|COMMON NAME||CHEMICAL NAME||CAS NO.||OSHA PEL||ACGIH TLV-TWA|
|Aromatic Solvent ||Light aromatic solvent naphtha ||64742-95-6 ||None Established ||None Established |
|Petroleum Hydrocarbon||Hydrotreated light distillates ||64742-88-7 ||None Established ||None Established |
|Primine Amine ||Primine Amine ||68955-53-3 ||None Established ||None Established |
|DTBP ||Di-tert-butyl Peroxide ||110-05-4 ||None Established ||None Established |
Contains no other ingredients now known to be hazardous as defined by OSHA 29CFR 1910.1000(z) and 29CFR 1910.1200.
These data are approximate or typical values and should not be used as precise specifications. Unless otherwise noted values are at 20°C(68°F) and 760 mmHg (1 atm).
|Specific Gravity (H20=1) @ 15.6°C
||Vapor Pressure (mm Hg)
|Vapor Density (Air =1)
||Solubility in Water (%)
|% Volatiles Organic Compounds (CARB)
||Evaporation Rate (Butyl Acetate = 1)
|pH (as is)
||pH (dilute) @ %
|| Clear straw color
|| Petroleum solvent
N/D - Not Determined
< = Less Than
N/A - Not Applicable
> = Greater Than
FIRE AND EXPLOSION HAZARD DATA
Flash Point 112°F(44°C)
Method Penksy-Martens Closed Cup, ASTM D-93
Flammable or Explosive Limits (Approximate percent by volume in air)
Lower (LEL) N/D Upper (UEL) N/D
Hazard Class Identification
0 - Least (insignificant)
1 - Slight
2 - Moderate
3 - High
4 - Extreme
Dry chemicals, carbon dioxide, foam, water fog.
Special Fire Fighting Procedures
Do not enter fire area without proper protection including breathing apparatus. Stay at safe distance. Use water
spray to cool fire exposed containers.
Unusual Fire and Explosion Hazards
Combustion may produce smoke, toxic fumes.
Conditions to Avoid
Sources of ignition such as heat, flames, sparks, etc.
Materials to Avoid
Acids, strong oxidizing agents such as nitrates.
Hazardous Decomposition or Combustion Products
Thermal decomposition may produce carbon dioxide, carbon monoxide and oxides of nitrogen.
Polymerization will not occur.
HEALTH HAZARDS/ROUTES OF ENTRY
Signs, Symptoms and Effects of Overexposure
Ingestion (swallowing) May be harmful or fatal if swallowed. Due to its low viscosity, it may enter lungs during
swallowing or vomiting. Once in lungs serious damage may occur.
Skin Contact can cause skin irritation, defatting of skin, redness.
Eye Contact Eye irritant.
Inhalation (breathing) May irritate nose, throat, and lungs. Prolonged or repeated exposure to vapor may cause
headache, dizziness, nausea, weakness and loss of coordination.
Other Effects of Prolonged/Repeated Overexposure
This material has not been identified as a carcinogen by NTP, IARC or OSHA. Above effects may be
aggravated with repeated overexposure.
EMERGENCY AND FIRST AID PROCEDURES
Ingestion (swallowing) call physician immediately. DO NOT induce vomiting
Skin Contact Remove all contaminated clothing. Wash thoroughly with soap and water. If signs of irritation develop,
seek medical attention.
Eye Contact Remove any contact lens. Flush with clean water for 15 minutes. If irritation develops or
persists, call a physician.
Inhalation (breathing) Remove person to fresh air. Call a physician if unconscious and for symptoms described
Comments NOTE TO PHYSICIANS: Ingestion or subsequent vomiting can result in aspiration of light hydrocarbon
liquid into the lungs which can cause pneumonitis.
SPILL OR RELEASE CONTROL PROCEDURES
Steps to be taken in case material is released or spilled
Eliminate all sources of ignition. Isolate and contain material, restrict entry to area. Insure adequate ventilation and
absorb with appropriate inert materials. Place absorbed material into waste containers.
Waste Disposal Method
Dispose of in accordance with Federal, State and Local regulations.
ENVIRONMENTAL HAZARD (EPA-CWA, SECTION 311)
Spills of this material leading to surface waters where it will cause a sheen must be reported to the National Response
Center, (800) 424-8802. This material is toxic to aquatic organisms and should be kept from sewage and drainage
systems and all bodies of water.
EPA Reportable Quantity (RQ), 40CFR302 (CERCLA104)
Acetone (5000 lbs)
EPA Toxic Chemical Release Reporting, 40CFR372(SARA313)
|Chemical ||CAS NO. ||% in Product|
|N/A ||N/A ||N/A|
HANDLING AND STORAGE
Handling and Storage Precautions
Warning: Contains combustible petroleum distillates. Avoid skin contact and breathing of vapors USE ONLY IN A
WELL VENTILATED AREA. Keep container closed. Keep away from flame, sparks or hot surfaces.
Use entire contents. DO NOT store opened containers. Keep out of reach of children.
PERSONAL PROTECTION - EXPOSURE CONTROL
Provide adequate general or local ventilation to maintain concentrations below TLV/PEL limits.
None normally required. If vapors exceed TLV/PEL values, use a NIOSH approved respirator
Safety glasses with side-shields.
Other Protective Clothing or Equipment
Eye wash station is recommended.
Personal cleanliness is always appropriate. Frequent washing minimizes chances of inadvertent exposure.
Department of Transportation (DOT) Classification
|Flammable Liquid|| ||Corrosive |
|Flammable Solid||Non Flammable Gas|
|Flammable Gas||Non Hazardous by DOT|
DOT Proper Shipping Name
N/A (Not regulated in quantities less than 119 gallons per container)
Air (IATA) and Ocean (IMDG) Shipments
Flammable liquid, N.O.S. (Contains Aromatic Solvent), 3, UN1993, PGIII
Product Code No.: 18001
Previous Code No.: 18001
Prior Date: 8-17-05
This information is, to the best of our knowledge and belief, accurate and reliable as of the date compiled. However, no representation, warranty or guarantee is made as to its accuracy, reliability or completeness. It is the user's responsibility to satisfy himself as to the suitability and completeness of such information for his own particular use.